LZS-1500-3现货 in stock! 欢迎来电咨询~！！

LZS-1500-3,

LZS-1500-3

有福之州-福州聚福兴供应进口工业控制系统成套备件：DCS PLC模块卡件，底板机架机槽，CPU模块，输入输出模块，模拟量模块，电源模块，通讯模块，工业交换机，触摸屏人机界面显示器，插头连接器，连接电缆接插电缆，伺服控制器，电机马达，伺服驱动器，驱动板电源板电路板，采集卡，影像卡，工控机，示教器，工业机器人配件..........
有福之州-福州聚福兴供应自动化供应进口品牌：罗克韦尔AB， Prosoft，西门子SIEMENS，施耐德SCHNEIDER，通用电气GE FANUC， 发那科FANUC，安川Yaskawa，欧姆龙Omron，三菱Mitsubishi，基恩士Keyence，东方步进Vexta，迈创Matrox，美家仪器NI，研华Advantech，莫迪康Modicon，思科Cisco，大隈Okuma，瑞士ABB，力士乐 Bosch Rexroth，台达Delta，福克斯波罗Foxboro，富士Fuji，霍尼韦尔Honeywell，惠普Hp，瑞恩 Reliance...........

欢迎咨询~~~~~

　　1 引言

　　纺丝机纺出的涤纶原丝需经过牵伸定型后,才具有一定的纤度、强度、伸度和其它的物理性能。VC443A牵伸加捻机用于涤纶复丝生产过程中牵伸加捻工序。牵伸丝为低捻复丝，可直接或经加弹工序后供绸厂使用。它的电气部分由电源控制系统、程序控制系统、锭子交流变频调速系统、热盘控制系统、热板控制系统组成。随着机电一体化技术的发展，对系统的可靠性要求愈来愈高，因PLC具有控制可靠、体积小、功能强、速度快,组态灵活和可扩展性的特点而得到了广泛的应用，成为自动化系统中的基本电控装置，故VC443A牵伸加捻机选用PLC可编程控制器，实现了生产的自动控制。

　　2 PLC选型设计

　　系统选用了日立公司的产品:E-64HR可编程控制器,作为主控单元，它有64个输入/输出点,其中40个开关量输入点，24个输出点，内置式电擦除EEPROM可以保护用户方便的完成程序和参数的修改和存储, PLC根据各输入点所接按钮，接近开关，接触器等电器信号的状态以及编制的软件程序自动控制各电机，电磁阀，指示灯等，完成整个生产的工艺动作程序，钢领板换向及成型自动控制。E-64HR具有多种编程工具:通用编程器PGMJ-R和标准编程器PGNJ等，体积小携带方便，可在现场实地进行程序调整和传送。全部控制程序约276条，可见该系统软硬件资源得到了相当充分的利用。

　　3 VC443A牵伸加捻机工艺

　　3.1 输入信号

　　VC443A牵伸加捻机控制系统的输入信号:主令按钮、限位开关、接近开关、钮子开关、拨盘开关的投入信号，全部为直流输入，共有40点。

　　3.2 输出信号

　　控制的负载主要分成三类:一是7台交流电机:牵伸双速电机M1、油泵电机M2、靠模升电机M3、靠模降电机M4、移丝电机M5、锭子电机M6、风机M7;二是用于控制钢领板升降及侧压辊压差的电磁阀;三是信号灯;四是计数器，共有24点，全部为继电器接点输出信号。

　　3.3 开车主要控制过程

　　(1) 按“油泵开”按钮SB7，使接触器KM5吸合， 油泵开指示灯亮, 油泵电机M2运转。(程序器的输出50对应的LED发光)。

　　(2) 按“低速开”按钮SB9。

　　●辅助接触器KA1吸合，锭子低速运转。(程序器的输出51对应的LED发光)

　　●程序器控制下，使计数器复零，进入准备工作状态，内部定时器T01 T02接通，使钢领板强迫进入废丝盘位置，待TO0延时到断开快速阀YV3，钢领板在程序器控制下微动。(程序器的输出76、65对应的LED发光，延时到熄灭，66、67对应LED交替发光)

　　●定时器TO1延时到，使接触器KM3吸合，牵伸双速电机M1带动牵伸罗拉和上下牵丝盘低速运转，低速指示灯亮，进入挂丝阶段。(程序器的输出52对应的LED发光)

　　(3) 按“高速开”按钮SB11。

　　●辅助接触器KA2吸合，使锭子高速运转。(程序器的输出53对应的LED发光)

　　●程序器控制使电磁阀YV4断电，侧压辊加压。(程序器输出64对应LED发光)

　　●定时器T02接通，延时到后接触器KM4得电，牵伸双速电机M1切换为高速运转，高速指示灯亮，继电器KA3吸合，移丝电机M5运转。(程序器输出54对应的LED发光。55对应的LED发光)

　　●定时器T03延时到后，钢领板强迫上升，靠模上撞块使底部打结开关SA2接通，定时器T04得电，使上升阀失电，实现底部打结，T04延时到上升阀YV1/1再次得电，强迫钢领板快速上升，进入正常牵捻区，待T05延时到后切断快速阀YV3，钢领板在程序器控制下，以正常速度运动，同时接通继电器KA4，靠模升电机M3运转，带动靠模缓慢上升，计数器开计长(程序器56对应的LED发光。65对应的LED在接通快速阀时发光，74对应的LED发光，有计长信号时发光指示)。

　　至此开车过程结束，机器进入正常纺丝。
 

Support 9302-TIDS SUPT RENEWAL CONTRACT FOR 9302TID

Support 9381-P5KENR SUPT REINSTATEMENT CONTRACT FOR 9381P5KEN

ControlNet Products 9355-WABOEMENE RSLINX OEM - ENGLISH

RSI Software Products 9324-RLD200FRE RSLOGIX 5000 MINI, FRA

RSI Software Products 9701-VWSB250DEU3 RSV SE STATION 250- SE SRV 250 DISP+CLIENT(GERMAN)

Motion Control MPL-A4540F-MK22AA MOTOR,SERVO,10.2 NM,3000RPM,MULTI,230V,9.5KG

Motion Control 2098-DSD-150 DRIVE, 65A/150A, ULTRA3000

CBL-138-2 Cable. Allen Bradley SLC500 1747-KE (RS-232)

HMI-KPN-302/B QUICKPANEL KEYPAD FOR 10.5" BLANK

IC693CPU363 CPU 363 Module (240K Bytes configurable user memory)

SPS-50W Discontinue - POWER SUPPY 24VDC 2.1AMP UL, CUL, CE

AKD-P00607-NBEC-0000

AIMB-542VE-00A1E

PCM-3730

ElanVital EVM-3507-00

BTX-400P4

MC8041A

VPM-54416-32M

1492-SPM1D040-N MCB Supplementary Protector 4 A

通用型变频器 6SE6 440-2UC33-7FA1 "37 KW,350 x 850 x 320"

电机启动器 3VU13403MH00

150-C37FBD Encl. SMC-3 37 A Smart Motor Controller

1609-P10000E Uninterruptible Power Supply P UPS Acces

1771-CE 1771 I/O CHASSIS CBL FOR 1771-P2 P/S

193-EC1ZZ E3 9-5000 A Overload Relay

198-F3 IEC Mounting Foot Enclosure Accessory

2090-CPBM7E7-14AF20 MP-Series 20 m Length Cable

2094-AC05-M01-S Kinetix 6000 Integrated Axis Module

CP9I-0MEB-0140-AZ "A50HVis Sh Motor Power Cable, Straight Connector, 14 M"

GFK-0265 Series 90-70 PLC CPU Instruction Set Reference Manual

IC200UEX214 28 point expansion. (16) 24VDC In, (12) 24VDC Out, 24VDC Power Supply (includes IC200CBL501)

IC647APC001 PA Production Client

IC647PDCH050 Ruggedized PDC Historian Base with 5000 Tags

IC693CHS393 Base, Remote Expansion, 10 Slots (700 ft.)

IC754CSL06MTD Ctrl Loaded 6 In Mono Touch DC

KIT-GFS-356 RX3i Workshop Student Kit

SLC/1746 System D1746-UM026AENP SLC 500 8 CHANNEL ANALOG OUTPUT MANUAL

Distributed I/O 1734D-IA16 120 VAC 16 IN, DNET COMMS, SCREW

Application-specific products 1405-M620-400 MINI POWERMONITOR M620 400V

Operator Interface 2711-T10C20L1 PV1000 COLOR TOUCH, ENET & RS232 PRINT

Support 9301-2SE3400ZHS SUPT RENEWAL CONTRACT FOR 93012SE3400ZH

Support 9381-PA250ENR SUPT REINSTATEMENT CONTRACT FOR 9381PA250EN

DeviceNet Products 1790D-8BV8V DNET LDX, 24VDC,8 UNIV IN/8 SINK OUT BASE, D-SHELL

RSI Software Products 9301-2SE3303KOE RSVIEW32 RUNTME 1500 WITH RSLINX (KOREAN)

RSI Software Products 9358-PBANT60ENE RSBATCH NT FOR PROCESSLOGIX ARCHIVER 60 UNITS

Motion Control MPL-B540K-SK24AA MOTOR,SERVO,19.4 NM,4000RPM,SINGL,460V,BRK,19.1KG

Motion Control 2090-UXLF-106 AC LINE FILTER,ULTRA,6 AMPS,1 PHASE

GQPL-DEM-C02 QUICKPANEL DEMO COLOR 12.1" GE LABEL

IC646MSP101 Logic Developer - State Professional w/Programming Cable

MTR-3T45-H-R-0-M-0 MTR-Series Servo Motor, Resolver, Metric

ST-121F STXi input module 16 points, Positive Logic, 12V/ 24VDC (connector type)

SCXI-1122

PCI-1750

超微 X7DWE

GA-X48-DS5

CANON SC-01A AG9-0498-02

AT-COM/V53A2 C24B1000-0A

1492-RCDA2C40 Residual Current Device 40 A

存储卡 6ES7952-1KM00-0AA0 FEPROM 存储卡， 4M

变送器 3RS10 40-1GD50

1497-G-BAJK-0-N Control Circuit Transformer

1606-XLDC40A 1606 Power Supply

1762-OB8 MicroLogix 8 Point Digital Output Module

188-K3D040-N Miniature Circuit Breaker 4 A

194L-HC6G-175 194L Control and Load Switch Actuator

2090-CPBM7DF-06AA40 MP-Series 40m Power and Brake Cable

2090-XXNPMF-10S90 MP-Series 90 m Length Cable

BC647TPD915 CIMPLICITY HMI ProServer 1500 I/O Development and Runtime System with Proficy GlobalCare

GC647PRTKIT002 GlobalCare Complete - Proficy Portal Enterprise Edition Starter Kit 2 User Ver 3.0

IC200MDL742 Output 24VDC POS LOGIC 0.5 amp per point(2 group of 16) with ESCP 32 points

IC646PEW110 OpenProcess Engineering Workstation (700 I/O)

IC647MRC000 Logic PC and View Runtime 8000 I/O with USB Hardware key

IC677PBI001 Profibus VersaMax IP Modular local bus master with (8) 24VDC inputs.

IC697RCM711RR Redundancy Communications Module (Hot Standby Redundancy)

IC800SSI228D2 28 amp 230 VAC Devicenet S2K servo controller for S-series motors

SLC/1746 System 1747-L532 SLC 5/03 CONTROLLER, 16K MEMORY

Industrial Computers 6181P-12NP2KH VERSAVIEW INTEGRATED DISPLAY COMPUTER 12-INCH TFT

Application-specific products 9358-PBA30ENE RSBIZWARE BATCH FOR PROCESSLOGIX ARCHIVER 30 UNITS

Operator Interface 2711-B5A9L1 PV550 MONO KEY&TOUCH, RS232 (DH485) & RS232 PRINT

Support 9303-3CS0EFFS SUPP RENEWAL CNTRCT FOR 9303-3CS0EFF

Support 9391-SDVEKS 9391-SDVEK SOFTWARE SUPPORT CONTRACT RENEWAL

ControlNet Products 2711-K5A15L2 PV550 MONOCHROME KEY, CNET & RS232 PRINT

RSI Software Products 9301-2SE2500KOU3 RSVIEW32 WORKS 300-100K UPGRADE IN-SUPT (KO)

RSI Software Products 9358-BEBNT30ENE RSBATCH / EPROCEDURE FOR NT BUNDLE 30 UNITS

Motion Control MPL-A4540C-HK22AA MOTOR,SERVO,10.2NM,1500RPM,ENCDR,230V,9.5KG

Motion Control 2090-XXNFMP-S15 CABLE,NON-FLEX,MOTOR FEEDBACK,MP/1326AB,15M

CBL-OIJR-12-RA Serial Cable, Operator Interface Panel (OIP) to S2K, Rt. Ang, 12 Ft.

IC641PCC010 Toolkit for integration of Visual Basic Applications

IC800SLT004 SL Amplifier Breakout Terminal Block for Third Party Controller Interface

PR-PAT-ABB01 Proficy PAT - Driver For Ethernet-Coupled Abb Bomem Ftir Spectrometers

PXI-6052E

PCA-6113P4R

080-0190-02-A

PC-612304

84G3711

SP-320-24

1492-MR6X8 IEC 6 x 8 mm Marker Card

1495-J6 CONTACT,AUXILIARY FOR STRTOR CONTACTOR

行程开关 3SE53120SB11

运行版软件 6AV2105-0FA04-0AA0 SIMATIC WinCC Runtime 专业版 2048 PowerTags V14

1585J-M4TBJM-3 RJ45 Ethernet Media

1756-OF4 ControlLogix 4 Point A/O I or V Module

188-K1C020-N Miniature Circuit Breaker 2 A

194E-G3707 194E 52 mm Metal Load Switch Shaft

2090-CFBM7DF-CEAA01 MP-Series 1m Servo Feedback Cable

2090-UXBK-D1501 Ultra series 1m Cable Breakout Board Kit

BC646OEM0401 OEM Edge Renewal - Historian

GC647DMS001 GC DataMart 1 PA Connection

IC200ALG262 Analog input 15 bit current differential 8 channel

IC646IFCLNTCRO010K iFIX iClient Read Only 10 PK Keyless (M1 Kit Part)

IC647IFPLSRUNLMTK iFIX Plus SCADA Unlimited Server (M1 Kit Part)

IC660MLR100 Label for IC660BBR100 (Qty 100)

IC697BEM733 Series 90-70 Genius Remote I/O Scanner

IC800APK130 SVU1-130 Alpha series 130 amp amplifier kit

ControlLogix/1756 System 1756-L55M14 LOGIX5555 PROCESSOR WITH 3.5MBYTE MEMORY

Industrial Computers 6182H-7BEH4D VVCE 700, KEY/TOUCH, EXT MEM, ENET, DC

Process Control 9358-BHIST02ENE RSBIZWARE BATCHHISTORIAN - 1 BATCH SERVER

Operator Interface 2711P-B15C6D1 PV PLUS 1500, KEY/TOUCH, RIO/DH, DC PS, STD MEM

Support 9240-MON16S SUPT RENEWAL CONTRACT FOR 9240MON16

Support 6723-PCOR SUPPORT REINSTATEMENT CONTRACT FOR 6723-PCO

Support F1794-ACNR15SERC FIRMWARE UPGRADE FOR 1794-ACNR15 I/O MODULE

RSI Software Products 9301-2SE2350U3R UPGRADE: OUT-SUPT: RSVIEW32 WORKS 1500 TO 5000

RSI Software Products 9351-HPUS INTERCHANGE FOR HP-UX

RSI Software Products 9399-WGMUG RSSERVER FOR GE FANUC MICRO USER GUIDE

Motion Control 8720MC-RFI80 SCHAFNER FN3100-80/35 FILTER FOR CE APPLICATIONS

BC646MRD700 Logic PC Runtime (HRT) 700 I/O

IC300RCSW250 RCS w/128K Ladder, 32Kb Rgisters, 1 port, SmartStack I/O

IC754VKI06MTD Starter Kit - 6" Monochrome QuickPanel View Intermediate, Touch, 24VDC

MTR-3T57-G-R-0-M-0RR Servo Motor Metric

PCI-8430/4

FSB-860B

SBC-456/E

CONTEC PIO-16/16L

AR-B1550

WG82574L

1492-LG3Q IEC Term Blck 5.1x79x31.3mm Spr Clp

1494F-V2 Combination Starter Door Hardware

软启动器 3RW44362BC36

ET 200SP 6ES7132-6BF00-0AA0 DO 8x24VDC/0.5A 基本型，基座单元类型 A0

1585D-E4UBDE-2 1585D Ethernet Media Patchcord

1753-L32BBBM-8A GuardPLC 1800 Safety Controller

1794-IE4XOE2 Flex 4 Input 2 Output Analog Module

194E-AA40EX-PE-TN 194E Load switch

2080-LC30-24QBB Micro830 24 I/O Controller

2090-CSWM1DF-18AA04 Kinetix Cable Single DSL 2090-Series

20AC3P5A3AYNANC0 PowerFlex 70 AC Drive 20A

GC646MPSS99 Proficy GlobalCare Complete for Logic Developer - PLC Standard Unlimited Seat Site License

HE693RTD600 RTD Input, 6 channel, 3-wire, 0.5C res., -100 to +850C range (Pt-100 )

IC610CPU106RR Series One Plus CPU, 3.7K Words

IC647HSTSC5KM Server to Server Collector for Historian - Standard Server 5000 Points (M4 Key)

IC660BBD021 Block 24/48Vdc Sink I/O 16 Circuits, 3 Wire Sensor Compatible

IC694PWR321CA Conformal Coated Power Supply 120/240VAC, standard.

IC756WDN009E-275 "DataViews Development System for Visual Basic, Java, C++ & Native C, 1 User, English v2.7.5"

MicroLogix 1500/1769 System 1769-RL2 REPLACEMENT DOOR LABELS FOR SPEC. I/O (2 PER KIT)

PLC-5/1771 System 1771-P5EK CONFORMALLY COATED,POWER SUPPLY,SLOT,8A,24V DC

Distributed I/O 1798-OB4E FLEXARMOR 4 POINT 24VDC SOURCING OUTPUT

Operator Interface 2711P-B6M5A PV PLUS 600 GRAYSCALE, KEY/TOUCH, RS232, AC PS

Support 9323-PA2JS SUPT RENEWAL CONTRACT FOR 9323PA2J

Support 9358-PB30R SUPT REINSTATEMENT CONTRACT FOR 9358PB30ENE

Support F1772-LZSERC FIRMWARE UPGRADE FOR 1772-LZ PLC2 PROCESSOR MODULE

RSI Software Products 9324-RLD6U7FRR RSLOGIX 5000 FULL TO PRO UPGRADE, EXP >90, FRENCH

RSI Software Products 9305-RSVADFVCENE RSVIEW32 ACTIVE DISPLAY FLOAT. VIEW CLNT (ENGLISH)

RSI Software Products 9301-PCI1500S7 APPLICOM PCI1500S7 PROFIBUS INTERFACE FOR SIEMENS

Motion Control 2094-BM02 MODULE, AXIS, 400/460V, 15A INV.

A06B-0158-B175#7008 A40/2000 Servo Motor, Fan Package, Holding Brake, 64K Serial Encoder

IC200UDR010 28 point; (16) 24VDC In, (11) Relay Out, (1) 24VDC Out, 24VDC Power Supply. Battery (IC200ACC403) is required for data retention. Battery not included.

IC752CBT023RR Datapanel 320T MEG (Mono Expansion w/Genius) w/ Advanced s/w: 320x240 1/4 VGA Mono LCD with 386SX/40 processor. Analog touch screen with text, bitmaps, bar graphs, real time clock. With Real Time Trends & Host Comms. With Genius PC/104.

MTR-1N33-N-A-S-0-MOD MTR series NEMA 34 stepping motor with parallel winding connection and special 0.5 inch diameter shaft

NI 9237

SSC-5X86H

Honeywell 65 871 046

PROX-1560S-N

PEAK 635-100

研祥PS-160

A06B-6035-H321

1492-SPM3D030-N MCB Supplementary Protector 3 A

软启动器 3RW40281BB05

"

150-SD2NUR SMC-50 SOLID STATE MOTOR CONTROLLER 420A

1738-ADN18 ArmorPoint DeviceNet Network Adaptor

1783-US7T1H Stratix 2000 7+1 port unmanaged switc

193-EXP-PS-DC E300 DC Expansion Power Supply

20-750-NEMA1-F5 PowerFlex 750 Frame 5 Conduit Box Kit

2090-CPWM7DF-16AF09 MP-Series 9m Length Power Cable

20AB022A0AYNANC0 PowerFlex 70 AC Drive 22 A at 7.5 Hp 20A

GA647IFESGSR00900 GCA iFIX Optn: ESig & ERec 900 I/O Srv

GP647IFCLNTCDV GCP iFIX iClient Dev

IC600BF808RR Interrupt Input Module (8 points)

IC647HSTCC250KM Calculation Collector for Historian - Standard Server 250000 Points (M4 Key)

IC647TBLCPVC025 Virtual Campus for Proficy Troubleshooter and Cause+ - 25 Users

IC693MDL760 Solenoid Valve Output (11 Points)/ 24VDC Output ,0.5 Amp, Positive Log ic (5 Points)

IC756LDV001E-925 "DataViews Development on Intel Linux/Red Hat, Addt'l User, English v9.25"

Pico Controllers 1760-CBL-INT03 PICO-LINK CONNECTIVITY CBL .8M 1 PCS/PACK

PLC-5/1771 System 1771-ODZ 120V AC OUTPUT MODULE (4 COMMONS)

Distributed I/O 1791-16AC BLOCK I/O, 120V AC, 32 POINT MODULE

Communications 1786-TJPR CONTROLNET 5" FLEXIBLE COAX JUMPER

Operator Interface 2706-NE1 INVIEW P22R ENCLOSURE, NEMA 12/13

Support 9701-VWSS025AS SUPT RENEWAL CONTRACT FOR 9701VWSS025AENE

Support 9324-RL0100ITR SUPT REINSTATEMENT CONTRACT FOR 9324RL0100IT

EtherNet/IP Products 1794-AENT ETHERNET ADAPTER W/24V DC POWEL SUPPLY, TWIST PR

RSI Software Products 9301-2SE340ZHU1R RSVIEW32 RUNTIME 1500-32K UPGRADE OUT-SUPT (ZH)

RSI Software Products 9356-PRO2450U1 UPGRADE: IN-SUPT: RSSQL STD.150 TO PROF.32000 TAG

Motion Control F-4075-R-H04AA MOTOR/ENCODER/BRAKE

4362-T 4362 WITH RS-232 OUTPUT

IC200ACC414 The ACC414 is a long term battery for the VersaMax Micro 23/28 point CPUs. The battery will backup upto 7 years. Marketing Mailing N -06-03-16

IC693MCD001 Demo case, Beta Series Servo

TGT-S00N-1-1 Target System Module with DeviceNet

CB-68LP

AIMB-641

OMI-LX534

D/300JCT-E1-120

EC3-1541CLDNA

ENG ASI-10M

SOM-2353

1492-SPM1D150-N MCB Supplementary Protector 15 A

通用型变频器 6SE6 440-2UD31-8DB1 18.5KW,275 x 520 x 245

电机启动器 3VU13401TB00

150-C480NCR SMC-3 480A Smart Motor Controller

1692-ZG3333 24 V DC Electronic Circuit Protection

1771-ID 1771 6 Point Digital Input Module

193-EC3CD E3 Plus 5-25 A Overload Relay

198-MT3 IEC On-Off Enclosure Accessory

2090-CPWM4DF-10AF05 MP-Series 5 m Length Power Cable

2094-AMP5-S Kinetix 6000 Axis Module

CW0DT256M/UGR 256M RAM Upgrade Kit for DuraTouch Industrial PC

GFK-0600 Series 90-70 Programmable Controller Data Sheet Manual

IC200UEX736 RTD expansion module for VersaMax Micro Pt 100, -100 to +600 C-150 to +1050 F 2 and 3 wire support and 2 analog output voltage and current.

IC647AQC010 PA Quality Client 10 Pak

IC647PLSVWR Proficy Pulse Viewer

IC693CHS399RR Base, Remote Expansion, 5 Slots (700 ft)

IC754UPGRD10CTRL QP Control OS Upgrade Qty-10